EAF dust가 포함된 붕규산염계 결정화 유리의 구조 및 화학적 내구성

안영수,강승구,Ahn, Y.S.,Kang, S.G. 한국결정성장학회 2007 한국결정성장학회지 Vol.17 No.2

붕규산염계 유리에 EAF Dust를 $40{\sim}80wt%$ 첨가하고 후 용융하여 유리를 제조한 후 $700^{\circ}C$/10hr으로 열처리하여 결정화유리 시편을 합성하였다. FT-IR, SEM, 그리고 EDS 분석을 통하여 조성 및 열처리 조건에 따른 시편내 결정상 및 결합상태 변화를 관찰하고, 이를 TCLP(Toxic Characterization Leaching Procedure) 실험에서 얻은 결과와 연계시켜 시편의 화학적 내구성을 연구하였다. 유리에 더스트 첨가량이 증가함에 따라 FT-IR 스펙트럼 상의 가교산소 진동피크($1050{\sim}1060cm^{-1}$)와 비가교산소 진동피크($960cm^{-1}$)가 합쳐진 넓은 피크($1000cm^{-1}$ 부근)가 저파수쪽으로 이동하였다. 동시에 boroxol ring의 $B_2O_3$ 구조가 tetrhedral-, trigonal- 그리고 di-borate로 변화되는 것을 확인하였다. 결정화유리 시편에서 Fe-O 피크가 확인되었으며 이는 spinel이 생성되었다는 XRD 결과와 일치하였다. TCLP를 행한 유리시편의 표면은 균열이 심하였으나 결정화유리는 큰 변화가 없어, 결정상 생성이 화학적 내구성을 향상시킴을 확인하였다. Fe의 용출량은 더스트가 80wt% 첨가된 결정화유리의 경우, 유리시편에 비하여 1/15로 감소하였다. Zn은 더스트 첨가량이 70wt% 이하인 결정화유리에서 용출량이 유리에 비해 높았으나 80wt% 이상 시편에서는 유리보다 감소하였고 이는 willemite 생성과 연관이 있는 것으로 사료된다. Glass-ceramics were fabricated by heat-treating a glass at $700^{\circ}C$/10hr which was obtained by melting a glass frit mixed with $40{\sim}80 wt%$ EAF dust at $1300^{\circ}C$/1hr. Dependence of crystal phase and bonding state change upon a compositional change and heat treatment condition were studied and the results was connected to the toxic characterization leaching procedure (TCLP) test data to investigate a chemical durability of the specimens. Increasing dust in a glass shifted the peak around $1000cm^{-1}$ to the lower frequency which was composed of two vibration peaks for the nonbridging oxygen at $960cm^{-1}$ and the bridging oxygen at $1050{\sim}1060cm^{-1}$. Also, the $B_2O_3$ structure of boroxol ring changed to a tetrhedral-, trigonal- and di-borate with dust addition. The Fe-O peaks in the glass-ceramics were observed which is consitent with XRD results of spinel formation. The surface of glass after TCLP test was severely cracked while there was no cracks on a glass-ceramics after TCLP test so the chemical durability of the glass-ceramics is superior than that of glass. The leaching concentration of Fe for the glass-ceramics containing EAF dust 80 wt% is 1/15 times lower than that of glass. The Zn leaching concentration fur the glass-ceramics containing dust < 70 wt% was higher than that of glass but its trend was reversed for the specimen of dust content > 80 wt% which could be concluded as correlated with occurrence of willemite phase.

EAF dust가 함유된 붕규산염계 결정화 유리의 미세구조 분석

안영수,강승구,김유택,이기강,김정환,Ahn, Y.S.,Kang, S.G.,Kim, Y.T.,Lee, G.K.,Kim, J.H. 한국결정성장학회 2006 韓國結晶成長學會誌 Vol.16 No.2

붕규산염계 유리 프리트에 중금속이 다량 함유된 전기로 EAF dust(전기로 제강분진, 이하 더스트)를 $10{\sim}80wt%$ 범위로 첨가한 후 용융하여 유리 시편을 얻었다. 제조된 유리의 DTA분석 결과로부터 유리전이온도, $T_g$가 $550^{\circ}C$ 부근임을 확인하였고 이로부터 결정화에 필요한 열처리 조건을 $700^{\circ}C$/10 hr으로 정하였다. 더스트 첨가량이 70wt% 이상인 유리시편은 XRD 분석 결과 spinel 결정 피크만이 나타났으며, 결정화 시편의 경우, 더스트 첨가량이 40wt% 이상부터 spinel 결정이, 80wt% 부터는 spinet과 willemite 피크가 함께 검출되었다. XRD 분석으로는 결정상이 검출되지 않았던 조성의 유리시편에서도 aspect ratio=$0.7{\sim}1.0$인 수십 nm 크기의 결정상 존재가 SEM으로 확인되었고 결정화 시편에서도 더스트 함량이 l0wt%부터 결정상이 관찰되었다. 결정화 시편에서 관찰된 결정상은 그 형태와 분포가 첨가량에 따라 다양하고 비균일 하였으나 더스트 첨가량이 70wt%인 시편에서는 aspect ratio가 1에 가까운 6면체 형상을 나타내었다. Glassy specimen was obtained by melting and quenching a borosilicate glass frit miked with $10{\sim}80wt%$ EAF dust. The glass transition temperature, $T_g$ of glassy specimen was measured around $550^{\circ}C$ from the DTA curve and the eat treatment condition to crystallize a glassy specimen was selected as $700^{\circ}C$/1 hr. The spinel crystal peaks were found in XRD analysis for the glass containing dust > 70 wt%. For the glass-ceramics, however, the spinel peaks in a specimen containing dust > 40 wt%, and the spinel and willemite peaks in dust > 80 wt%. The crystals of several tens of nanometer with aspect ratio of $0.7{\sim}1.0$ were observed at a glassy specimen containing dust > 40 wt% by SEM which was not found by XRD analysis. For the glass-ceramics, the crystals were found in a specimen containing dust of even 10 wt% by SEM. The feature and distribution of crystals observed through the specimen for a glass-ceramics were diverse and not uniform. The crystals found in the glass-ceramics containing 70 wt% dust were hexahedral with an aspect ratio of around unity.

저온관류 흰쥐 심방표본의 Catecholamine 및 Ouabain 반응에 관한 연구

안영수,배영숙,Ahn, Y.S,Pae, Y.S 대한약리학회 1977 대한약리학잡지 Vol.13 No.1

Recently several reports have claimed that the bath temperature changes, such as lower bath temperature, produce supersensitivity on the positive chronotropic effect of catecholamine in cat, mouse and guinea pig atria. However, others showed controversial results against temperature-dependent supersensitivity. Similarly, the inotropic effect of ouabain is diminished in febrile state, however some investigators indicated that cardiac glycoside showed less toxicities and less effects in hypothermic condition. In this study, the effects of norepinephrine and epinephrine on inotropy and chronotropy in isolated rat atria was investigated by changing the temperature of bath ($30^{\circ}C$, $^35{\circ}C$ and $38^{\circ}C$). In addition, the effects of ouabain on atria in hypothermic bath was also studied. The followings are the results. 1. At the lower bath temperature isolated rat atrial rate was decreased and contractility was increased. 2. The chronotropic responses to norepinephrine and epinephrine in $38^{\circ}C$ were decreased when the bath temperature lowered to $35^{\circ}C$ or $30^{\circ}C$, while the inotropic responses were not affected. 3. Hypothermic supersensitivity to norepinephrine or epinephrine was not observed in rat atrium. 4. The inotropic response to ouabain was potentiated but chronotropic response was diminished by a lowering in the bath temperature. In conclusion, the chronotropic response of rat atrium to catecholamine was decreased, however, hypothermic supersensitivity was no longer present in rat atrium and the inotropic response of ouabain was increased at lower bath temperature.

산조인의 중추신경 및 심혈관계에 대한 약리작용

안영수,김경환,조태순,김원준,홍사석,Ahn, Y.S.,Kim, K.H.,Cho, T.S.,Kim, W.J.,Hong, S.S. 대한약리학회 1982 대한약리학잡지 Vol.18 No.1

Zizyphus seed(Zizyphus vulgaris Lamark var. Spinosus Bunge) has long been used as hypnotics and sedatives in oriental medicine, and it is reported that the Zizyphus seed elicited a variety of pharmacologic actions besides CNS depression. Present study was undertaken to investigate the effects of Zizyphus seed on the central nervous system and on the blood pressure. The effect of Zizyphus seed on the central nervous system was measured by the influence of thiopental sleeping time and by inhibition of chemical convulsion (strychnine and pentylenetetrazol induced). Blood pressure changes by Zizyphus extract and its mode of action were investigated. The ground Zizyphus seed was extracted with hexane and methanol, consecutively and the supernatants were discarded. The precipitate was re-extracted with distilled water and the supernatant was evaporated to a dark-brownish sticky liquid, which was used as Zizyphus seed extract in this study after dissolving in saline prior to experiment. The results are as follows. 1) Zizyphus seed extract caused marked prolongation of the thiopental sleeping time in mice. 2) The chemical convulsion by strychnine and pentylenetetrazol, and the mortality by them in chicks were not affected by pretreatment of Zizyphus seed extract. 3) Zizyphus seed extract produced transient fall of blood pressure in the cat, and this hypotentive effect was blocked partially by atropine but not affected by bilateral vagotomy and/or hexamethonium, nor propranolol and, chlorpheniramine and/or cimetidine. With the above results, it may be suggested that the water extract of Zizyphus seeds contains components producing CNS depression and hypotension. Furthermore it is felt that the cholinergic effect, but not the adrenergic or histaminergic, is partly responsible for the hypotensive effect of Zizyphus seed extract.

10 L급 미세조류 배양용 평판형 광생물 반응기 케이스 개발에 관한 연구

안동규(D. G. Ahn),조창규(C. G. Cho),안영수(Y. S. Ahn),정상화(S. H. Jeong),이동기(D. G. Lee) 한국정밀공학회 2011 한국정밀공학회 학술발표대회 논문집 Vol.2011 No.6월

광경화 방식의 3 차원 프린팅 기술을 이용한 고효율 광생물 반응기 시작품 제작

안동규(D. G. Ahn),조창규(C. G. Cho),안영수(Y. S. Ahn),정상화,김종태 한국정밀공학회 2014 한국정밀공학회 학술발표대회 논문집 Vol.2014 No.5월

늑막액의 당 및 단백분획상

김원준(W.J. Kim),안영수(Y.S. Ahn),김혜영(H.Y. Kim),이원영(W.Y. Lee) 대한약리학회 1979 대한약리학잡지 Vol.15 No.1

Previous studies concerning the usefulness of pleural fluid glucose levels in differentiating causes of pleural effusions have been conflicting. Gelenger and Wiggers (1949), Calnan et al(1951) and Barber et al(1957) concluded that the lower the level of pleural fluid glucose, the more likely was tuberculosis, and that tuberculosis was unlikely if the pleural fluid glucose level was more than 80 mg/100 ml. Light and Ball(1973), however, reported that in the great majority of tuberculous pleural fluids the glucose concentration was high rather than low, concluded that the pleural fluid glucose levels were not useful in the differential diagnosis of pleural effusion. In this study, pleural fluid glucose was determined in 46 pleural effusions from various causes to evaluate the usefulness in the differential diagnosis of pleural effusion. In addition, the protein concentration and the electrophoretic patterns of protein and amylases in pleural fluid was compared with that of serum. And the results were as follows. 1. The mean glucose concentration of pleural fluid was 80.8 mg/100 ml in 22 tuberculous origin, 92.5 mg/100 ml in 12 cancer patient and 70.4 mg/100 ml in 10 undiagnosed cases. In 2 cases of paragonimiasis the pleural fliud glucose levels were low (mean, 32.0 mg/100 ml). The percentage of pleural fluid protein to serum is about 75% in all disease groups and the protein level of tuberculous pleural fluid was significantly correlated with that of serum. 2. The disc eletrophoretic patterns of pleural fluid were almost similar with that of serum in all disease groups but the prealbumin fraction was not observed in pleural fluid. 3. With the isoelectric focusing, 4 to 7 isoamylase was observed in serum and the isoelectric point was ranged from pH 5.8 to 7.8 and isoelectic point of main fracticn is pH 7.2. The isoelectic focusing patterns of amylase of pleural fluid were identical to that of serum in all disease group. With the above results it is concluded that the pleural fluid is exudate of serum and that the glucose levels of pleural fluid are not useful in the differential diagnosis of pieural effusions.

한국산(韓國産) 사독(蛇毒)에 관(關)한 실험적(實驗的) 연구(硏究)

김원준(Kim, W.J.),안영수(Ahn, Y.S.),김주덕(Kim, J.D.),김세환(Kim, S.W),홍사석(Hong, S.S.) 대한약리학회 1976 대한약리학잡지 Vol.12 No.2

Agkistrodon halys (Crotalidae) is the only species of poisonous snakes in Korea, and is divided into three subspecies; Agkistrodon bromhoffii brevicaudus, Agkistrodon calaginosus and Agkistrodon saxatilis. With the three venoms, the pharmacological actions on the cardiovascular system and intestine as well as some toxicological characteristics were studied. In addition, the precipitin test in an agar gel medium was employed for immunological comparison of the venoms and the sera of envenomed patients. The results obtained were as follows: Lyophilized venoms contained solids of 211 ~ 273mg/ml, and LD50 to mice were 1.73 and 0.86 mg/kg in venoms of Agkistrodon bromhoffii brevicaudus obtained on July and October respectively, and 0.40 and 0.32 mg/kg in Agkistrodon calaginosus and the venoms of Agkistrodon saxatilis obtained on October was 2.29 mg/kg. Isoelectric focusing of lyophilized snake venoms showed 19 to 22 protein fractions and 2 to 3 isoamylase fractions. Acute irreversible hypotension was caused by the intravenous injection of large doses of venoms in rabbits and cats, but at the small doses, acute hypotension followed by slow recovery. Little changes of cardiac movements by the venom injection despite of marked hypotension were showed except bradycardia and arrhythmia prior the death. Also no changes on the isolated rabbit atria by the snake venoms were noted. The hypotensive effect of the snake venoms was prevented by the bilateral vagotomy or atropine pretreatment (1 mg/kg), but they did not affect when already the hypotension has undergone. In the isolated rabbit duodenum, small doses of venom increased the phasic movement, while large doses decreased after spastic contraction. With the injection of venoms in dog, strong contraction of gall-bladder was caused and it was not blocked by the pretreatment with phenoxybenzamine (10 mg/kg) or atropine (1.4 mg/kg). In the venoms of Agkistrodon bromhoffii brevicaudus and Agkistrodon calaginosus, at least 5 antigenic components were detected, and four of them were shared in common with each other. Polyvalent antivenin (Wyeth Lab. USA) had three common precipitating antibodies with the venom of Agkistrodon bromhoffii brevicaudus and Akistrodon calaginosus. In the serum of envenomed patients, no precipitating antibodies were seen to the venoms and little changes in serum protein, GOT and GPT were observed. In conclusion, the snake venoms obtained in Korea were highly toxic and caused chiefly the vascular collapse leading to death. This vascular collapse was resulted largely by cholinergic effects, and not cardiotoxin of venoms. In human, it is likely that precipitating antibodies to venom were not produced by an envenomed incidence to poisonous snakes.

특징형상을 가진 평판형 광생물 반응기 Scale-up 에 관한 연구

이호진(H. J. Lee),안동규(D. G. Ahn),조창규(C. G. Cho),안영수(Y. S. Ahn) 한국정밀공학회 2014 한국정밀공학회 학술발표대회 논문집 Vol.2014 No.5월

폴리카보네이트 판재의 고온 인장 특성 분석

이호진(H. J. Lee),안동규(D. G. Ahn),안영수(Y. S. Ahn) 한국정밀공학회 2013 한국정밀공학회 학술발표대회 논문집 Vol.2013 No.10월